4/23/2025, 6:46:21 AM 星期三
基于紧密堆积理论的低密度固井水泥浆设计
CSTR:
作者:
作者单位:

1.中国地质大学(武汉)工程学院,湖北 武汉 430074;2.中国地质大学(武汉)非常规固井与特种加固实验室,湖北 武汉 430074

中图分类号:

TE256

基金项目:

国家重点研发计划项目“乳品废水乳糖母液基微生物固井技术”(编号:2016YFE0204300);国家自然科学基金项目“水合物分解对深水固井水泥环孔隙特征与力学性质的影响机制研究”(编号:42072343)


Design of low density cementing slurry based on close packing theory
Author:
Affiliation:

1.Faculty of Engineering, China University of Geosciences, Wuhan Hubei 430074, China;2.Unconventional Cementing & Special Reinforcement Laboratory, China University of Geosciences,Wuhan Hubei 430074, China

  • 摘要
  • | |
  • 访问统计
  • |
  • 参考文献 [33]
  • |
  • 相似文献 [20]
  • |
  • 引证文献
  • | |
  • 文章评论
    摘要:

    合理的颗粒级配是提高固井水泥环内部密实度、早期力学强度和界面胶结能力的关键。基于此,本文从几种典型的连续颗粒级配的紧密堆积理论中优选出DFE进行固井水泥浆体系设计,并通过大量实验首次确定了适宜G级油井水泥基深水固井水泥浆体系设计的n值最优范围:0.33~0.40。结合激光粒度分析仪实测结果,在粒径≤3.38 μm、3.38~70.70 μm、≥70.70 μm三个范围内依次采用纳米CaCO3(nano CaCO3,以下简称“NC”)、G级油井水泥和漂珠,并按DFE(n=0.33~0.40)体积分布曲线进行混配。在此基础上,提出一种密度为1.50 g/cm3的低成本低温早强三元固相级配水泥浆体系,并与漂珠二元固相水泥浆体系和NC二元固相水泥浆体系的性能进行对比。研究结果表明:该三元体系水泥石的抗压强度、抗折强度和二界面胶结强度相比于漂珠二元体系和NC二元体系分别提高了7%~21.1%、13.4%~51.9%和41.4%~122.2%。三元体系的固井水泥石在垂向上的最大密度差为0.022 g/cm3。基于DFE设计的三元体系具有良好的流变性、稳定性和力学性能。DFE对于多元固井水泥浆体系的设计和应用具有一定的指导意义,在保证低密度的前提下能够有效地提高固井水泥石的早期强度和综合性能。

    Abstract:

    Reasonable particle size distribution is the key to improve the internal compactness, early mechanical strength and interfacial bonding ability of cementing cement sheath. Based on this, Dinger-Funk equation (hereinafter referred to as “DFE”) is selected to design cementing slurry system from several typical close packing theory of continuous particle gradation. Through a large number of experiments, the optimal range of n value suitable for the design of cement slurry for oil and gas wells is determined for the first time: 0.33~0.40. Combined with the measured results of laser particle size analyzer, nano CaCO3 (hereinafter referred to as “NC”), grade G oil well cement and floating beads are successively used in the three particle size ranges of ≤3.38μm, 3.38~70.70μm and ≥70.70μm, and mixed according to the volume distribution curve of DFE (n=0.33~0.40). On this basis, a low-cost, low-temperature and early strength ternary solid-phase graded cement slurry with a density of 1.50g/cm3 was proposed, and its performance is compared with that of the floating bead binary cement slurry and NC binary cement slurry. The results show that: the compressive strength, flexural strength and interfacial bonding strength of the ternary system are increased by 7%~21.1%,13.4%~51.9% and 41.4%~122.2% respectively compared with the binary system of floating beads and NC. The maximum vertical density difference of cementing cement is 0.022g/cm3. The ternary system based on DFE has good rheology, stability and mechanical properties. DFE has certain guiding significance for guiding the design and application of multiple cementing cement slurry system, and can effectively improve the early strength and comprehensive performance of cementing cement under the premise of ensuring low density.

    参考文献
    [1] 步玉环,侯献海,郭胜来.低温固井水泥浆体系的室内研究[J].钻井液与完井液,2016,33(1):79-83.BU Yuhuan, HOU Xianhai, GUO Shenglai. Study on low temperature cementing slurry[J]. Drilling Fluid & Completion Fluid, 2016,33(1):79-83.
    [2] Oort E V, Hoxha B B, Hale A. Thermal wellbore strengthening through managed temperature drilling-Part II: Chemical system design and laboratory testing[J]. Journal of Natural Gas Science & Engineering, 2018,58:275-284.
    [3] Kiran R, Teodoriu C, Dadmohammadi Y, et al. Identification and evaluation of well integrity and causes of failure of well integrity barriers (A review)[J]. Journal of Natural Gas Science and Engineering, 2017,45:511-526.
    [4] 刘天乐,郑少军,王韧,等.固井水泥浆侵入对近井壁水合物稳定的不利影响[J].石油学报,2018,39(8):937-946.LIU Tianle, ZHENG Shaojun, WANG Ren, et al. Negative effect of cementing slurry invasion on gas hydrate stability around borehole wall[J]. Acta Petrolei Sinica, 2018,39(8):937-946.
    [5] 许明标,曾晶,唐海雄,等.适于海洋深水固井的零稠化转化时间低温水泥浆体系研究[J].石油天然气学报,2007(3):104-107.XU Mingbiao, ZENG Jing, TANG Haixiong, et al. Research on a cement slurry for deepwater cementing operation in zero thickening transition period at low temperature[J]. Journal of Oil and Gas Technology, 2007(3):104-107.
    [6] 王成文,王瑞和,步玉环,等.深水固井水泥性能及水化机理[J].石油学报,2009,30(2):280-284.WANG Chengwen, WANG Ruihe, BU Yuhuan, et al. Properties and hydration mechanism of deepwater cementing system[J]. Acta Petrolei Sinica, 2009,30(2):280-284.
    [7] Le R D, Sylvaine. Cementing compositions and applications of such compositions for cementing oil wells or the like:EP19990963494[P]. 2003-10-12.
    [8] 周仕明,李根生,王其春.超高密度水泥浆研制[J].石油勘探与开发,2013,40(1):107-110.ZHOU Shiming, LI Gensheng, WANG Qichun. Research and preparation of ultra-heavy slurry[J]. Petroleum Exploration and Development, 2013,40(1):107-110.
    [9] Biezen E, Ravi K. Designing effective zonal isolation for high-pressure/high-temperature and low temperature wells[J]. Society of Petroleum Engineers, 1999(1):57583-MS.
    [10] Weerd A, Aghbari S, Hanshi S, et al. Innovative application of foamed cement for zonal isolation of a tieback casing across highly corroded casing[C]. Society of Petroleum Engineers. 2010(1):128261-MS.
    [11] 席方柱,屈建省,吕光明,等.深水低温固井水泥浆的研究[J].石油钻采工艺,2010,32(1):40-44.XI Fangzhu, QU Jiansheng, LV Guangming, et al. Study of deepwater low-temperature cement slurry[J]. Oil Drilling & Production Technology, 2010,32(1):40-44.
    [12] 刘慧婷,刘硕琼,齐奉忠.紧密堆积优化固井水泥浆体系研究进展[J].硅酸盐通报,2014,33(9):2269-2274.LIU Huiting, LIU Shuoqiong, QI Fengzhong. Research progress of cement slurry system optimized by dense packing theory[J]. Bulletin of the Chinese Ceramic Society, 2014,33(9):2269 -2274.
    [13] 唐明,陈勇.论混凝土材料的高功能化[J].混凝土,2001(3):14-18.TANG Ming, CHEN Yong. Discussion high functional concrete material [J]. Concrete, 2001(3):14-18.
    [14] 黄柏宗.紧密堆积理论优化的固井材料和工艺体系[J].钻井液与完井液,2001,18(6):1-9.HUANG Baizong. New cementing materials and technique developed on the concept of high packing density[J]. Drilling Fluid & Completion Fluid, 2001,18(6):1-9.
    [15] 滕兆健,龚智宇,燕平,等.紧密堆积在HFY油田盐膏层固井水泥浆中的应用[J].西部探矿工程,2019(1):17-20.TENG Zhaojian, GONG Zhiyu, YAN Ping, et al. Application of close packing theory in cementing slurry of salt gypsum layer in HFY Oilfield [J]. West-China Exploration Engineering, 2019(1):17-20.
    [16] Piot B, Ferri A, Mananga S P, et al. West africa deepwater wells benefit from low-temperature cements[C]. Society of Petroleum Engineers, 2001.(67774-MS).
    [17] Tsubasa S, Kenichi S, Muhannad A. Water absorption and shrinkage behavior of early-age cement in wellbore annulus[J]. Journal of Petroleum Science and Engineering, 2018, 169:205-219.
    [18] 齐志刚.低温低水化热固井水泥浆体系研究[D].青岛:中国石油大学,2009.QI Zhigang. Research on a low temperature and low hydration heat cement slurry system[D]. Qingdao: China University of Petroleum, 2009.
    [19] 顾军,陶雷,干品,等.天然气水合物钻探低温低密度水泥浆体系优选试验[J].探矿工程(岩土钻掘工程), 2018,45(1):24-27.GU Jun, TAO Lei, GAN Pin, et al. Optimization test of low-temperature and low-density cementing slurry system for natural gas hydrate drilling[J]. Exploration Engineering (Rock & Soil Drilling and Tunneling), 2018,45(1):24-27.
    [20] Rao G A. Generalization of Abrams’ law for cement mortars[J]. Cement & Concrete Research, 2001,31(3):495-502.
    [21] Furnas C C. Grading Aggregates I. Mathematical relations for beds of broken solids of maximum density[J]. Ind.Eng.Chem, 1931,3:1052-1058.
    [22] Fuller W B, Thompson S E. The laws of proportioning concrete[J]. Journal of the Society for Chemical Industry, 1934,53(2):107-115.
    [23] 乔龄山.水泥的最佳颗粒分布及其评价方法[J].水泥,2001(8):1-5.QIAO Lingshan. The optimum particle size distribution of cement and its assessment method[J]. Cement, 2001(8):1-5.
    [24] 乔龄山.细粉材料颗粒特性、堆积密度和混凝土泌水性的新检验方法[J].水泥,2007(5):1-8.QIAO Lingshan. A new test method for particle characteristics, bulk density and concrete bleeding of fine powder materials[J]. Cement, 2007(5):1-8.
    [25] Horsfield H T. The strength of asphalt mixtures[J]. Journal of the Society for Chemical Industry, 1934,53(2):107-115.
    [26] Goltermann P, Johansen V, Palbol L. Packing of aggregates: An alternative tool to determine the optimal aggregate mix[J]. Aci Materials Journal, 1997,94(5):435-443.
    [27] Jones M R, Zheng L, Newlands M D. Comparison of particle packing models for proportioning concrete constitutents for minimum voids ratio[J]. Materials & Structures, 2002,35(5):301-309.
    [28] Bonneau O, Poulin C, Dugat J, et al. Reactive powder concretes: From theory to practice[J]. Concrete International, 1996,18(4):47-49.
    [29] Andreasen A H M. Zur kenntnis des mahlgutes[J]. Kolloidchemische Beihefte, 1928,27(6-12):349-358.
    [30] Funk J E, Dinger D R. Particle packing, part 1: Fundamentals of particle packing monodisperse spheres[J]. Interceram,1992, 41(1):10-14.
    [31] Dinger D R, Funk J E. Particle packing, part Ⅴ: Computational methods applied to experimental distributions[J]. Interceram, 1994,43(2):87-89.
    [32] 唐明,潘吉,巴恒静.水泥基粉体颗粒群分形几何密集效应模型[J].沈阳建筑大学学报(自然科学版),2005,21(5):515-518.TANG Ming, PAN Ji, BA Hengjing. The model of the cementing matrix powder group fractal geometry denseness effect[J]. Journal of Shenyang Jianzhu University (Edition of natural Science), 2005,21(5):515-518.
    [33] 程荣超,王瑞和,王成文,等.基于分形级配理论的油井水泥体系设计及评价[J].中国石油大学学报(自然科学版),2008,32(6):83-87.CHENG Rongchao, WANG Ruihe, WANG Chengwen, et al. Design and evaluation of oil well cement system based on fractal grading theory[J]. Journal of China University of Petroleum (Edition of Natural Science), 2008,32(6):83-87.
    网友评论
    网友评论
    分享到微博
    发 布
引用本文

郑少军,王凯伦,刘思雨,等.基于紧密堆积理论的低密度固井水泥浆设计[J].钻探工程,2021,48(3):94-100.
ZHENG Shaojun, WANG Kailun, LIU Siyu, et al. Design of low density cementing slurry based on close packing theory[J]. Drilling Engineering, 2021,48(3):94-100.

复制
分享
文章指标
  • 点击次数:833
  • 下载次数: 1076
  • HTML阅读次数: 1025
  • 引用次数: 0
历史
  • 收稿日期:2020-10-29
  • 最后修改日期:2021-01-21
  • 录用日期:2021-01-22
  • 在线发布日期: 2021-03-22
  • 出版日期: 2021-03-10
文章二维码